Volvo 340 Workshop Manuals and Repair Manuals
Every Manual available online - found by our community and shared for FREE. Enjoy!
Volvo 340
The Volvo 300 Series is a rear wheel drive automobile sold as both a hatchback and (later) a conventional saloon from 1976 to 1991. . The series consisted of the Volvo 340 (initially badged as the 343/345) and the later Volvo 360. Overall, the 300 series was considered heavy and unrewarding to drive but reliable and safe by the standards of its day. The 300 Series had a choice of three petrol engines; a 1.4, 1.7, and a 2.0-litre. A diesel engine for the 340 developing 54 PS (40 kW), was only available in certain markets and was added to the 340 models in 1984. In 1985 a 360 diesel was made available.Volvo 340 FAQ's
How do I adjust the headlights on a Volvo 340?
To adjust the headlights on a Volvo 340, you will need to locate the headlight adjustment screws under the hood. There are typically two screws per headlight, one for vertical adjustment and another for horizontal adjustment. Park the vehicle on a level surface facing a wall or garage door, turn on the headlights, and mark the center of each beam's pattern on the wall. Using a suitable screwdriver or wrench, adjust the screws to align the beam pattern with the marked center position. Regularly check the alignment to ensure optimal visibility and proper beam aim.
How do I change the oil in a Volvo 340?
To change the oil in a Volvo 340, you will need to locate the oil drain plug underneath the engine and remove it with a wrench. Allow the old oil to fully drain into a suitable container before replacing the drain plug. Then, remove the oil filter and replace it with a new one, ensuring it is properly tightened. Lastly, refill the engine with the recommended type and amount of oil, as specified in the owner's manual.
How do I check the brake fluid level in a Volvo 340?
To check the brake fluid level in a Volvo 340, locate the brake fluid reservoir under the hood. The reservoir is usually located near the firewall on the driver's side of the engine bay. The fluid level should be visible through a transparent section on the side of the reservoir. Ensure the vehicle is on a level surface, remove the cap from the reservoir, and visually inspect the fluid level. If the fluid is below the minimum mark, it should be topped up with the appropriate brake fluid recommended by the manufacturer.
How do I replace a fuse in a Volvo 340?
To replace a fuse in a Volvo 340, locate the fuse box, which is usually located in the engine compartment or in the passenger compartment, depending on the specific model and year. Open the fuse box and identify the fuse that needs to be replaced by referring to the fuse diagram or labeling inside the fuse box cover. Using a fuse puller or a pair of needle-nose pliers, gently remove the faulty fuse and replace it with a new fuse of the same amperage rating. Ensure the new fuse is securely fitted, then close the fuse box.
How do I replace a headlight bulb in a Volvo 340?
To replace a headlight bulb in a Volvo 340, first, open the hood and locate the back of the headlight assembly. Remove the electrical connector from the bulb by squeezing the tab and pulling it off. Next, twist and remove the bulb socket counterclockwise, then pull out the old bulb. Insert a new bulb into the socket, making sure it is securely seated, and reinstall the socket into the headlight assembly by twisting it clockwise. Finally, reconnect the electrical connector and test the headlight before closing the hood.
How do I replace a wheel bearing in a Volvo 340?
To replace a wheel bearing in a Volvo 340, start by safely raising the vehicle and removing the wheel and tire assembly. Next, remove the brake caliper and rotor to gain access to the wheel bearing hub assembly. Disconnect the ABS
How do I replace the battery in a Volvo 340?
To replace the battery in a Volvo 340, first, ensure the ignition is in the off position and all electrical accessories are turned off. Locate the battery, usually located in the engine compartment. Disconnect the negative (black) cable from the battery terminal first, followed by the positive (red) cable. Remove any retaining brackets or clamps holding the battery in place and carefully lift it out of the battery tray. Install the new battery in the reverse order, connecting the positive cable first, then the negative cable. Ensure the connections are secure and tight.
How do I replace the cabin air filter in a Volvo 340?
To replace the cabin air filter in a Volvo 340, locate the filter housing, which is typically located behind the glove compartment or under the dashboard on the passenger side. Remove the access panel or cover to reveal the cabin air filter. Take note of the direction of airflow indicated on the old filter. Slide the old filter out of the housing and discard it. Insert the new cabin air filter into the housing, ensuring it is properly oriented with the airflow direction. Reinstall the access panel or cover, and ensure it is securely fastened.
How do I replace the spark plugs in a Volvo 340?
To replace the spark plugs in a Volvo 340, start by locating the spark plug wires or ignition coil packs. Disconnect the wires or coil packs from the spark plugs by gently pulling them straight off. Use a spark plug socket and a ratchet or a spark plug wrench to remove the old spark plugs by turning them counterclockwise. Check the gap on the new spark plugs to ensure they match the specifications provided in the owner's manual, and then install them by hand, followed by tightening them with the spark plug socket and ratchet. Finally, reconnect the spark plug wires or ignition coil packs.
How do I replace the windshield wipers on a Volvo 340?
To replace the windshield wipers on a Volvo 340, lift the wiper arm away from the windshield and locate the release tab or button on the blade assembly. Depress the tab or press the button to detach the old wiper blade from the arm. Then, align the new wiper blade with the arm and push it into place until it clicks securely. Gently lower the wiper arm back onto the windshield and repeat the process for the other wiper blade.
How do I reset the service light on a Volvo 340?
To reset the service light on a Volvo 340, first, ensure the ignition is in the off position. Then, press and hold the trip odometer reset button while turning the ignition key to the on position without starting the engine. Continue holding the button until the service light starts flashing, then release it. Turn off the ignition, wait a few seconds, and then start the engine. The service light should now be reset.
How do I troubleshoot a starting issue in a Volvo 340?
When troubleshooting a starting issue in a Volvo 340, start by checking the battery voltage and ensuring it is fully charged. Inspect the battery terminals and cables for any corrosion or loose connections, cleaning or tightening them as necessary. Check the fuel level and make sure the vehicle has enough fuel. If the battery and fuel are not the issue, examine the ignition system, including the spark plugs, ignition coil, and starter motor. If necessary, consult the repair manual or seek assistance from a qualified mechanic to diagnose and resolve the starting issue.
How often should I replace the air filter in a Volvo 340?
The air filter in a Volvo 340 should typically be replaced every 12,000 to 15,000 miles or every 12 months, whichever comes first. However, if you drive in dusty or polluted environments more frequently, it may be necessary to replace the air filter more often. Regularly inspecting the filter for excessive dirt or debris buildup is also recommended, and if it appears dirty or clogged, it should be replaced regardless of mileage or time intervals.
What are the recommended tire pressures for a Volvo 340?
The recommended tire pressures for a Volvo 340 can vary depending on the specific model, year, and tire size. However, as a general guideline, the front tires are usually recommended to be inflated to around 30-32 psi (pounds per square inch), while the rear tires are typically advised to be inflated to approximately 28-30 psi. It is important to check the owner's manual or the tire placard located inside the driver's door jamb for the precise recommended tire pressures for your particular Volvo 340.
What type of coolant should I use in a Volvo 340?
The recommended coolant for a Volvo 340 is a mixture of ethylene glycol-based antifreeze and distilled water. The exact ratio of antifreeze to water may vary depending on the climate and temperature range in which the vehicle operates. It is advisable to use a pre-mixed coolant solution specifically formulated for Volvo vehicles or consult the owner's manual for the precise coolant specifications and mixing ratios. Regularly check the coolant level and top it up with the appropriate mixture when necessary.
Volvo 340 on Amazon
Volvo 340 Workshop Manual
-
- Volvo 340 Workshop Manual
- (1,707 Pages)
- (Free)
Volvo 340 Misc Document
- (Free)
Related Models
