Volvo 850 Workshop Manuals and Repair Manuals

Every Manual available online - found by our community and shared for FREE. Enjoy!

Volvo 850

The Volvo 850 is a compact executive car produced by the Swedish manufacturer Volvo Cars from 1991 to 1997 and designed by Jan Wilsgaard. Available in sedan/saloon and station wagon/estate body styles, the 850 was the first front-wheel drive vehicle from Volvo to be exported to North America. It also was the first all-wheel drive Volvo sold on the US market. It was produced with various diesel and petrol engines, and was available with both manual and automatic transmission styles. It was Volvo s top-seller in the mid-1990 s and popular for its lower cost and fuel economy.

Volvo 850 FAQ's

How do I change the oil in my Volvo 850?

To change the oil in your Volvo 850, first, locate the oil drain plug underneath the engine. Use a wrench to loosen and remove the plug, allowing the old oil to drain into a suitable container. Once all the oil has drained out, replace the drain plug and proceed to remove the oil filter. Install a new filter and then refill the engine with the recommended amount of fresh oil, making sure to use the correct viscosity and quality specified in the owner's manual.

How do I diagnose a misfiring engine in my Volvo 850?

If you are experiencing a misfiring engine in your Volvo 850, there are a few steps you can take to diagnose the issue. Start by checking the spark plugs to ensure they are in good condition and properly gapped. Inspect the ignition coils and spark plug wires for any signs of damage or wear. Additionally, it's recommended to scan the vehicle's onboard diagnostic system for any trouble codes that could provide further insight into the misfire issue.

How do I replace a headlight bulb on my Volvo 850?

To replace a headlight bulb on your Volvo 850, first, open the hood and locate the back of the headlight assembly. Remove the connector from the bulb by gently pulling it straight out. Next, twist the bulb counterclockwise and remove it from the assembly. Install the new bulb by aligning the tabs and twisting it clockwise until it locks in place. Finally, reconnect the connector and test the headlight to ensure it is functioning correctly.

How do I replace the brake pads on my Volvo 850?

To replace the brake pads on your Volvo 850, start by securing the vehicle on a level surface and engaging the parking brake. Remove the wheel from the corner where you want to replace the brake pads. Locate the brake caliper and remove the retaining bolts to access the brake pads. Take note of the position and orientation of the old brake pads, then remove them and install the new ones. Ensure that the brake caliper is properly aligned and secure, then repeat the process for the other wheels.

How do I replace the cabin air filter in my Volvo 850?

To replace the cabin air filter in your Volvo 850, locate the filter housing, which is typically located behind the glove compartment. Remove the screws or latches securing the housing and open it to access the old filter. Take note of the filter's orientation and remove it. Install a new cabin air filter, making sure it is properly aligned, and close the housing. Secure the housing back in place, ensuring all screws or latches are tightened.

How do I replace the fuel filter on my Volvo 850?

To replace the fuel filter on your Volvo 850, start by relieving the fuel system pressure by disconnecting the fuel pump fuse and allowing the engine to run until it stalls. Locate the fuel filter, which is typically located along the fuel line, near the fuel tank or engine. Use a wrench to loosen and remove the fittings on each end of the filter. Install the new fuel filter, ensuring the fuel flow direction is correct, and tighten the fittings. Finally, reconnect the fuel pump fuse and start the engine to verify proper fuel flow.

How do I replace the serpentine belt on my Volvo 850?

To replace the serpentine belt on your Volvo 850, start by locating the belt tensioner, which is typically located near the top of the engine. Use a wrench or socket to rotate the tensioner counterclockwise, releasing tension on the belt. Slide the old belt off the pulleys and carefully release the tensioner. Route the new belt around the pulleys following the correct path as indicated in the belt routing diagram. Finally, rotate the tensioner counterclockwise again, allowing the new belt to be installed onto the pulleys.

How do I replace the windshield wiper blades on my Volvo 850?

To replace the windshield wiper blades on your Volvo 850, lift the wiper arm away from the windshield and locate the release tab or button on the wiper blade. Press or slide the release mechanism to detach the old blade from the wiper arm. Align the new wiper blade with the wiper arm and attach it firmly until it clicks into place. Finally, lower the wiper arm back onto the windshield and test the new blades for proper operation.

How do I reset the service light on my Volvo 850?

To reset the service light on your Volvo 850, insert the key into the ignition and turn it to position I (accessory). Press and hold the trip odometer reset button while turning the key to position II (on, but not starting the engine). Continue holding the trip odometer reset button until the service light flashes and resets. Release the button and turn off the ignition. When you turn the ignition on again, the service light should be reset.

How do I troubleshoot a malfunctioning air conditioning system in my Volvo 850?

If your Volvo 850's air conditioning system is not functioning properly, there are a few troubleshooting steps you can take. First, check the fuse related to the A/C system and replace it if necessary. Next, inspect the A/C compressor and ensure that the belt is properly tensioned and not damaged. If these steps do not resolve the issue, it's recommended to consult the repair manual for further troubleshooting or seek the assistance of a qualified mechanic.

How do I troubleshoot a non-functioning power window in my Volvo 850?

If you have a non-functioning power window in your Volvo 850, start by checking the fuse related to the power windows and replace it if necessary. Inspect the power window switch for any signs of damage or malfunction. If the switch is functioning correctly, it's recommended to test the power window motor and regulator for proper operation by applying power directly to the motor. If the motor operates, but the window still does not move, it may indicate a problem with the window regulator mechanism that may require replacement.

How do I troubleshoot an electrical issue in my Volvo 850?

When troubleshooting an electrical issue in your Volvo 850, it's important to start by checking the fuses related to the affected components. Inspect the wiring harnesses for any signs of damage or loose connections. If the issue persists, consult the repair manual for the specific wiring diagrams and electrical component locations to further diagnose the problem. Additionally, using a multimeter to test voltage and continuity can help pinpoint the source of the electrical issue.

How often should I change the transmission fluid in my Volvo 850?

The recommended interval for changing the transmission fluid in your Volvo 850 is typically around every 30,000 to 60,000 miles, or every 3 to 4 years, depending on the driving conditions and usage. However, it's important to consult the owner's manual for the specific recommended interval for your particular model and year. Regularly changing the transmission fluid helps maintain optimal performance and prolongs the lifespan of the transmission components.

What is the recommended tire pressure for a Volvo 850?

The recommended tire pressure for a Volvo 850 can vary depending on the specific model and tire type. However, in general, the recommended tire pressure for the front and rear tires is typically around 30-35 psi. It's important to check the owner's manual or the sticker located on the inside of the driver's door or fuel filler door for the precise recommended tire pressure for your specific Volvo 850 model.

What type of coolant should I use in my Volvo 850?

Volvo recommends using a high-quality ethylene glycol-based coolant that is compatible with aluminum components for your Volvo 850. It is important to use a coolant that meets the specifications provided in the owner's manual to prevent any potential damage to the cooling system. Additionally, it's crucial to mix the coolant with distilled water in the correct ratio as specified in the owner's manual for optimal performance and protection against freezing or overheating.

Volvo 850 Manuals Index

Volvo 850 Workshop Manual

Volvo 850 Owners Manual

Volvo 850 Misc Document

Related Models

Volvo 850 on Amazon

Volvo 850 Service and Repair Manual (Haynes Service and Repair Manuals)